Inspection

Inspection Details

Equipment ID
21711

Inspection Date
3/5/2018

Inspection Type
Annual Inspection

Inspector Name
Unknown Conversion

Mechanic Name

Relief Valve Pressure
620

Slide

Governor Rope Pull

Door Closing Force
F14 R20

External ID

Location

Gateway Science Academy - South
6651 Gravois Ave., St. Louis, MO
Phone: (314) 669-9000

Owner

6651 Gravois LLC
6651 Gravois Ave., St. Louis, MO 63116

Billing

Attn: 6651 Gravois LLC

6651 Gravois Ave, , MO 63116

Violations

Code	Item	Section	Reinspection	Reason For Violation	Fixed Date
MO Minimum : Elevators	(H) - Machine Rooms	(H)2		The machine room door shall be self-closing and self-locking.
MO Minimum : Elevators	(I) - Pits	(I)6 (Pit Lighting)		The pit light shall be operational.
MO Minimum : Elevators	(A) - Hoistways	(A)1		The hoistway door sill grout on the outside of the "G" landing shall be repaired.
MO Minimum : Elevators	(A) - Hoistways	(A)3		Adjust the "G" level hoistway door to close properly.
MO Minimum : Elevators	11 CSR 40-5.090 Inspection and Testing	(3) Testing Procedures (Re-Inspect)	x	The category 5 full load testing shall be completed. The only item of the category 5 test that was able to be completed was the relief pressure with a full load. All other category 5 testing items remain.	3/1/2021
MO Minimum : Elevators	11 CSR 40-5.090 Inspection and Testing	(3) Testing Procedures (Re-Inspect)	x	There were issues getting the unit to operate properly. All annual inspection items still need to be tested with the exception of the relief pressure.	3/1/2021
MO Minimum : Elevators	(G) - Maintenance, Repair and Replacements	8.6.5.5.2 Oil Leakage Collection		A means shall be provided to collect the overflow oil from the jack head.
MO Minimum : Elevators	(I) - Pits	(I)1		There is an excessive amount of oil on the pit floor. The pit shall be kept clean and dry.
MO Minimum : Elevators	(I) - Pits	(I)6 (Pit Lighting)		The pit lighting shall be operational.
MO Minimum : Elevators	(F) - Electrical Switches	(F)6	x	Reverse phase relay has been removed and a jumper has been installed in its place. Replace proper device.	8/29/2022
MO Minimum : Elevators	11 CSR 40-5.090 Inspection and Testing	8.6.5.16.5 Over Speed Valve Testing		This elevator is equipped with an over speed valve that in not sealed. A category 5 test shall be performed on the over speed valve in 2021 or 2022. The valve shall be sealed and tagged after the category 5 test.
MO Minimum : Elevators	(S) - Fire Service	211.7 Firefighters Operations/Signage		Provide Phase 1 & 2 fire fighters instructions.
MO Minimum : Elevators	11 CSR 40-5.090 Inspection and Testing	(3) Testing Procedures (Re-Inspect)	x	The low pressure switch does not work and shall be operational.	8/29/2022
MO Minimum : Elevators	(G) - Maintenance, Repair and Replacements	(G)1- 8.6.4.15 Car Emergency Systems (Emergency Light) (Re-Inspection)	x	The in car emergency telephone shall be operational.	8/29/2022
MO Minimum : Elevators	(S) - Fire Service	211.7 Firefighters Operations/Signage		Firefighters phase one instructions shall be posted near the phase one key-switch in the hallway at the egress floor.
MO Minimum : Elevators	(S) - Fire Service	211.7 Firefighters Operations/Signage		Firefighters phase two instructions shall be posted inside the car on the car operating panel.
MO Minimum : Elevators	(G) - Maintenance, Repair and Replacements	8.6.1.6.7 Signs and Data Plates		The fire service phase one key-switch bezel shall be legible.
MO Minimum : Elevators	(B) - Car Enclosure: Passenger	(B)8 Car Lighting		The illumination inside the car enclosure shall be operational. Note: One of the two lighting fixtures inside the car aren't working.
MO Minimum : Elevators	CSR 40-5.100 State Operating Certificate	5.100(2) Display of Operating Certificate		A current MO State operating certificate shall be posted in the elevator equipment room, in a noncombustible frame with a clear protective vision plate over it. Note: Display certificate is expired.
MO Minimum : Elevators	(B) - Car Enclosure: Passenger	(B)8 Car Lighting		Car enclosure lights shall be operational.
MO Minimum : Elevators	(G) - Maintenance, Repair and Replacements	(G)1- 8.6.4.15 Car Emergency Systems (Emergency Light) (Re-Inspection)	x	Emergency light shall be operational.
MO Minimum : Elevators	CSR 40-5.100 State Operating Certificate	5.100(2) Display of Operating Certificate		A current MO State operating certificate shall be posted near the equipment, in a noncombustible frame with a clear protective vision plate over it.

Back